面對環氧樹脂地坪失光現象應該怎么處理

環氧地坪漆的優點是與基層的粘接強度高，硬化時收縮率極低，不易開裂；整體無縫，易清洗，不集聚灰塵、細菌；強度高，耐磨損，經久耐用；抗?jié)B透，耐化學藥品的腐蝕性能強，對油類也有較好的容忍力；室溫固化成膜，容易維修保養；表面平整光滑，色彩豐富，能美化工作環境、地面無毒，符合衛生要求。環氧地坪漆失光了怎么辦，不要著急，環氧地坪漆來教你如何避免和處理環氧樹脂地坪的失光。

The advantages of epoxy floor paint are high bonding strength with the base, low shrinkage rate during hardening, not easy to crack; seamless, easy to clean, not gathering dust and bacteria; high strength, wear resistance, durable; anti-penetration, chemical resistance, corrosion resistance, and good tolerance to oils; room temperature curing film forming. Easy maintenance; smooth surface, rich color, beautifying the working environment, non-toxic ground, in line with health requirements. What if the epoxy floor paint loses its gloss? Don't worry. The epoxy floor paint teaches you how to avoid and deal with the gloss of the epoxy floor. 

1、環氧地坪漆物面處理不干凈，含有酸、堿、油污、蠟質和水分等。這就要求我們施工前，被涂物表面應充分處理干凈。

1. The surface treatment of epoxy floor paint is not clean. It contains acid, alkali, oil, wax and water. This requires that before construction, the surface of the coating should be fully treated and cleaned.

2、被涂物表面過分粗糙或多孔，未涂封閉底漆會發生環氧地坪失光現象。此種原因引起的環氧樹脂地坪失光就需要我們物面應用底漆封閉，膩?zhàn)犹钇?，打磨?/p>

2. The surface of the coated material is too rough or porous, and the epoxy floor will lose its gloss if the primer is not sealed. The loss of gloss of epoxy floor caused by this kind of reason requires us to apply primer to seal the surface, fill the putty and polish it.

3、施工場所濕度太大(相對濕度超過85%)，揮發性漆的涂膜容易吸收水分而發白發光。預防：施工場所的濕度不宜過大。

3. The humidity of the construction site is too high (relative humidity is over 85%). The film of volatile paint is easy to absorb moisture and emit white light. Prevention: The humidity of construction site should not be too high.

4、涂膜軟，耐劃傷性能不好。預防：按被涂物的使用條件，選用耐候性、抗劃傷性能良好的涂料。

4. The coating is soft, and the scratch resistance is not good. Prevention: According to the application conditions of the coatings, the coatings with good weatherability and scratch resistance are selected.

5、漆中顏料的水分含量過高或施工中混入水分。

5. The moisture content of paint is too high or mixed with water in construction.

6、預防：應控制顏料的含水量，施工中避免混入水分。

6. Prevention: Water content of pigments should be controlled to avoid mixing in water during construction.

7、施工中稀釋劑用量過多或加入了煤油一類的高沸點稀釋劑。預防：稀釋劑用量不宜過多，應避免煤油一類的高沸點溶劑的加入。

7. Excessive amount of diluent or high boiling point diluent such as kerosene are added in construction. Prevention: The dosage of diluent should not be too much, and the addition of high boiling point solvent such as kerosene should be avoided.

8、涂膜未完全干透之前遇雨水或露水。預防：涂膜在干燥過程中要防止雨水或露水浸潤。

8. Rainwater or dew will be encountered before the film is completely dried. Prevention: The film should prevent rain or dew from soaking in the drying process.

根據以上分析可以看出，環氧地坪漆環氧地坪的施工技術和習慣是造成失光的重要原因之一，養成規范的施工技術和施工環境要求，按標準施工流程操作就可以避免防治環氧樹脂地坪漆出現失光機率。

According to the above analysis, it can be seen that the construction technology and habits of epoxy floor paint is one of the important reasons for the loss of light. Forming the standard construction technology and construction environment requirements, according to the standard construction process operation can avoid preventing and curing the loss of light of epoxy floor paint.